Audi 90 AC Blower Motor Parts
Showing 1 out of 1 part(s) found in our catalog.
Brand
Keyword
Subcategory
Mon-Fri 8-4 MST/PST (Arizona Time)
Based on industry averages you can expect to pay between $45.99 and $45.99 for a Audi 90 ac blower motor.
Why Is My Audi 90 AC Blower Motor Not Working?
If your Audi 90 AC blower motor stops working, there are several things that might be going on. Sometimes, it’s as simple as a blown fuse or a failed relay. The resistor pack can give out, especially as the car gets older. In some cases, debris can block the fan or the motor itself can seize up. You might even run into a loose connector or corroded wires. To figure it out, start by checking the fuses and relays, then look for signs of damage or burnt smells near the blower motor. Getting to the motor usually means pulling out the glove box. While you’re there, check for power at the motor and see if the control switches inside the car are doing what they should. If none of this brings the blower back to life, the motor might need to be replaced. Also, don’t overlook the climate control head unit—sometimes, the problem comes from inside the dash controls, not the blower itself.
How Do You Replace An Audi 90 AC Blower Motor?
To replace your Audi 90 AC blower motor, start by disconnecting the battery. Safety first—nobody likes a surprise shock. Remove the glove box or the lower dash trim to get access to the blower motor tucked inside the HVAC housing. Unplug the motor’s connector, take out the screws or remove the clips holding it in place. The blower comes out with a bit of wiggling, but watch the fan blades—they snap easily. Installing the new motor is mostly just working in reverse, but sometimes you need to move the old fan onto the new motor if it doesn't come with one. Some people put a drop of oil on the new motor’s bushings before locking it back in. Once it’s all set, put the glove box or trim back, reconnect the battery, and give it a test run. If it spins up and pushes air, you're good to go.
What Causes Strange Noises From The Audi 90 AC Blower Motor?
Weird noises from your Audi 90 AC blower motor can show up out of nowhere. Sometimes it’s debris like leaves or twigs rattling around in the fan. Bearings or motor bushings wear out, leading to squeaks or grinding. Now and then, some old foam insulation works loose and gets caught in the fan, making it buzz or hum. If you start hearing new sounds, take the blower out and give it a look. Usually, you’ll find the reason—cleaning out the debris or adding a bit of lubricant can quiet things down quick. But if the noise sticks around, or if you see dust or metal shavings by the fan, the motor might be going bad and needs to be swapped out.
How Can You Test If The Audi 90 AC Blower Motor Is Faulty?
To see if your Audi 90 AC blower motor is the problem, check that it’s getting power. Use a multimeter or a test light and see if voltage is arriving at the blower motor connections when the controls are set to different speeds. If there’s power but nothing happens, the blower motor’s probably done for—either the windings burnt out or the brushes failed. If you want to be sure, hook up the motor directly to the battery. If it runs, the trouble’s not in the motor but somewhere in the wiring, resistor pack, or control switch. If it stays dead even with direct power, there’s your answer—it’s time for a new blower.
Why Does The Audi 90 AC Blower Motor Only Work On Certain Speeds?
When your Audi 90 AC blower motor only spins at high speed or just one setting, the blower resistor is often the culprit. This part lets you pick different speeds, and when it fails, you usually lose everything except high. A burned resistor pack leaves you either with one speed or none at all. It’s also possible for the control switches, wiring, or relay to create the same problem, but the resistor is usually to blame—especially on older cars like the Audi 90. Swap it out, and most of the time, your blower speeds come right back.
Looking For An Audi 90 AC Blower Motor With Fast Shipping And Easy Returns?
At AutohausAZ, we understand how much hassle car repairs can be. That’s why we work hard to give you a smooth experience when you need an Audi 90 AC blower motor. Our prices stay honest—no wallet shock. Plus, we keep shipping quick, so you’re not left waiting with a hot or stuffy car. We know things don’t always go right on the first try, so we keep returns easy and straightforward. If you have a question or need advice, our team’s here for you, not just during the sale but after too. Whether you’re handling your own repairs or just trying to save on a mechanic’s bill, you can count on us for reliable parts and real support every step of the way.
